SEC-04 • Energy Isolation & Electrical • 29 CFR 1926.400–449 (Subpart K) & 29 CFR 1910.301–399 (Subpart S) & NFPA 70E (2024)

Electrical Safety, Arc Flash & NFPA 70E Compliance Program

Qualified vs. Unqualified electrical worker rules, electrically safe work condition (ESWC), Energized Electrical Work Permits, Shock (Limited/Restricted) and Arc Flash Boundaries, Arc-Rated PPE Categories 1–4, and GFCI / AEGCP cord rules.

Buy Single Written Program ($49) → Buy All 24 Programs — Complete Manual ($149) Open in Full Interactive Customizer

Mandatory OSHA & RAVS® Audit Elements Covered

Every Electrical Safety, Arc Flash & NFPA 70E Compliance Program document generated by Trade Safety Manuals is pre-merged with your Company Name and Designated Safety Director and addresses these required regulatory provisions:

  • De-energize all circuits ≥50V before work unless de-energizing creates a greater hazard or is infeasible (requires signed Energized Electrical Work Permit)
  • Live-Dead-Live voltage verification using a CAT III / CAT IV digital multimeter before touching any conductor
  • Establishment of Limited Approach, Restricted Approach, and Arc Flash Boundaries per NFPA 70E
  • 100% GFCI protection (or Assured Equipment Grounding Conductor Program) on all 120V, 15A/20A temporary jobsite receptacles and extension cords
OSHA Construction Standard: 29 CFR 1926.400–449 (Subpart K)
OSHA General Industry Standard: 29 CFR 1910.301–399 (Subpart S) & NFPA 70E (2024)
RAVS® / Portal Category: Energy Isolation & Electrical
Required Employee Training Interval: Initial Qualified Person training + NFPA 70E refresher at least every 3 years + annual contact-release refresher
Competent Person Inspection Frequency: Daily extension cord & GFCI test; rubber insulating gloves air-tested before each use and lab-tested every 6 months

Required PPE & Instant Custom Sample Download

Mandatory Personal Protective Equipment (PPE) & Controls Specified:

  • Arc-Rated Clothing (8 to 40+ cal/cm² per category)
  • ASTM D120 Voltage-Rated Rubber Insulating Gloves with Leather Protectors
  • Insulated Tools (ASTM F1505)
  • Dielectric Hard Hat & Arc Face Shield

Customize & Download Free Sample (.DOC)

Enter your company details below to download an editable Microsoft Word copy of SEC-04: Electrical Safety, Arc Flash & NFPA 70E Compliance Program immediately:

Upgrade to Complete 24-Chapter Manual + State Plan ($149) →

Browse All 24 Written OSHA & RAVS® Safety Programs:

SEC-01: Injury & Illness Prevention Program (IIPP) / Corporate Safety PolicySEC-02: Fall Protection, Guardrails & Post-Fall Rescue PlanSEC-03: Control of Hazardous Energy — Lockout / Tagout (LOTO)SEC-04: Electrical Safety, Arc Flash & NFPA 70E Compliance ProgramSEC-05: Trenching, Excavation & Underground Utility ProtectionSEC-06: Permit-Required Confined Space Entry (Construction & General Industry)SEC-07: Respirable Crystalline Silica Written Exposure Control PlanSEC-08: Hazard Communication (HazCom) & GHS Safety Data Sheets ProgramSEC-09: Fire Prevention, Welding, Cutting & Hot Work Permit ProgramSEC-10: Portable Ladders, Stairways & Safe Access ProgramSEC-11: Supported & Mobile Scaffolding Safety ProgramSEC-12: Mobile Elevating Work Platforms (MEWPs) — Aerial & Scissor LiftsSEC-13: Cranes, Derricks, Rigging & Qualified Signal Person ProgramSEC-14: Personal Protective Equipment (PPE) & Hazard Assessment ProgramSEC-15: Heat Illness Prevention, Acclimatization & Hydration PlanSEC-16: Hand & Portable Power Tools, Guards & Pneumatic/Powder-Actuated ToolsSEC-17: Respiratory Protection, Medical Evaluation & Fit Testing ProgramSEC-18: Heavy Earthmoving & Mobile Equipment, Spotters & Traffic ControlSEC-19: Compressed Gas Cylinders, Refrigerants & Mechanical Piping SafetySEC-20: Bloodborne Pathogens, First Aid & Sewage/Biohazard Exposure ControlSEC-21: Emergency Action Plan (EAP), Medical Evacuation & Severe WeatherSEC-22: Incident Investigation, Root Cause Analysis & OSHA 300 RecordkeepingSEC-23: Subcontractor Safety Prequalification & Multi-Employer CoordinationSEC-24: Occupational Noise Exposure & Hearing Conservation Program